Sharp AF-P80CX Manual de servicio Pagina 1

1AF-P80CXS3208AFP08CX/SERVICE MANUALPageSPECIFICATIONS ...

10AF-P80CXOFF TIMER OPERATION• This unit has a built-in timer that can be programmed to shut the unit off up to 12 hours in advance. Youcan set the ti

11AF-P80CXRemove the battery compartment cover.Insert the batteries in the compartment,making sure the and polaritiesare properly aligned.

12AF-P80CXON / OFFSELECTORSET TIMER / OFFPOWERON / OFFTEMP.• The time setting will change as you push the button. The displaywill change as follows;•

13AF-P80CXON / OFFSELECTORSET TIMER / OFFPOWERON / OFFTEMP.PLASMACLUSTER OPERATIONDuring operationCluster ions are released into the room, keeping air

14AF-P80CXNOTE FOR PLASMACLUSTER OPERATIONThe ionizer inside the air conditioner will discharge cluster ions, which are collectivemass of positive and

15AF-P80CX108673451210987654321ACCESSORIESNo.Accessories Q'tyRight closure assembly 1Left closure assembly 1Window sash foam seal 11. Screw dri

16AF-P80CXInsert the right closure assembly and theleft closure assembly into the top angleand the bottom channels.Secure the right and left clos

17AF-P80CX1/2 inches(13mm) Indoor sideIndoor side78Secure the top angle of the unit and thetop of the closure assemblies to the sashwith three of t

18AF-P80CX1. Unscrew the 2 screws holding the front panel on eachside.DISASSEMBLING PROCEDURECAUTION: DISCONNECT THE ROOM AIR CONDITIONER FROM THE POW

19AF-P80CX10. Cut the wire fixing band, slide the control box rightwardand remove.14. Unscrew the 2 screws holding the condenser shround.And remove th

2AF-P80CXSPECIFICATIONSModels AF-P80CXCooling capacity BTU/h 8000Moisture removal Pints/h 2.3ELECTRICAL DATAPhase SingleRared frequency Hz 60Rated vol

20AF-P80CX19. Unscrew the 1 screw holding the centrifugal fan. 20. Unscrew the 1 screw holding wire holder.Unscrew the 3 screws holding fan motor.DISA

21AF-P80CXPROPER FLUXINGFlux is necessary when using silver solder; it is not requiredwhen using silfos on copper to copper joints.To do a good job t

22AF-P80CXOUTER CONEHOTTEST PARTOF FLAMEINNER CONETORCH STEMFigure 4Composition of Torch Flame.HEATING THE TUBINGDirect the torch flame so that the la

23AF-P80CXELECTRICAL COMPONENT TESTRUNNING CAPACITOR AND FAN CAPACITORCAUTION: DISCHARGE THE RUNNING CAPACITOR AND FAN CAPACITOR BEFORE TOUCHING CAPAC

24AF-P80CXMICROCOMPUTER CONTROL SYSTEMFigure Y-12. Operation mode2-1 COOL operationThe compressor turns on or off, at thermostat lines C1and C2. The f

25AF-P80CXTable Y-3T(˚C) T(˚F) R(kΩ) V(volts)0 32.0 49.33 1.171 33.8 46.86 1.212 35.6 44.53 1.263 37.4 42.33 1.314 39.2 40.25 1.365 41.0 38.29 1.416

26AF-P80CXElectronic Control Circuit DiagramCA1: 1000pF x 8 (CAPACITOR ARRAY)RA1: 10kΩ x 8 (RESISTOR ARRAY)IF NOT SPECIFIED 1/5W, ±5% (RESISTOR)IF NOT

27AF-P80CXPrinted Wiring BoardQPWBFB471JBZZQPWBFB471JBZZDPWBFA277JBKZDPWBFA277JBKZJP35JP28JP29JP30191018C2

28AF-P80CXTROUBLESHOOTING GUIDENo cooling(Operation not at all.)Measure the power supply voltage at receptacle.Is it sufficient current capacityof pow

29AF-P80CXNo cooling (Fan operate but the compressor doesn't operate.)Ask the power supplycompany for check.Ask the power supplycompany for check

3AF-P80CXGROVERLOADPROTECTORA.CEARTHM.CCONNECTORHMLFAN MOTOR CAPACITOR250V 6µFFAN MOTOR RUNNINGCAPACITOR250V 35µFTHERMALPROTECTORBLBLBLBKBKBKGYREORW

30AF-P80CXNo cooling(The compressor operate butthe fan motor doesn't operate)Check BNC1 on PWB ass'yOKOKOKNGNGcrack at the solder partdiscon

31AF-P80CXInsufficient cooling(Both compressor and compressor operate)Check the temperature setting.too highdirtydirtynot dirtynot dirtyOKcloseOKNGNGU

32AF-P80CXExcessive vibrationor Abnormal noiseAt fan only mode,Excessive vibration or Abnormal noiseCheck the air filterNOOKNGOKOKOKOKOKOKOKtoo bigNGt

33AF-P80CXCOOLING LOAD ESTIMATE FORMINSTRUCTIONS FOR USING COOLING LOAD ESTIMATE FORM FOR ROOM AIR CONDITIONERS(AHAM PUB. NO. RAC-1)A. This cooling lo

34AF-P80CXHEAT GAIN FROM QUANTITYFACTORSDAYBTU/Hr(Quantityx Factor)1. WINDOWS: Heat gain from sun.SoutheastNortheastSouthSouthwestSoutheastWestNort

35AF-P80CXRUNNING CONDITIONNote:1. Select mode of the Running Condition of a Room Air Conditioner.SELECTOR ...

36AF-P80CXPACKING AND ACCESSORIESTop pad RTop pad L4TOP PAD ASSEMBLY (DPADBA006JBFZ)AccessoriesOperation manualWindow sash foam sealWindow sash sealBo

37AF-P80CXREPLACEMENT PARTS LISTREF. NO. PART NO. DESCRIPTION Q'TY CODECABINET AND UNIT PARTS1- 1 CMOTLB003JBEZ Fan motor 1 BM1- 2 DCHS-A364JBTA

38AF-P80CXREF. NO. PART NO. DESCRIPTION Q'TY CODEHOW TO ORDER REPLACEMENT PARTSTo have your order filled prompty and correctly, please furnish th

39AF-P80CX1234512345 66ABCDEFGHABCDEFGHCABINET PARTS1-241-41-31-351-26-176-176-96-92-75-35-65-15-41-365-25-51-146-21-381-331-156-136-131-176-86-171-45

4AF-P80CXEXTERNAL DIMENSIONS19-11/16"35-7/16" (full opened)23-5/8" (full closed)17-3/32" 13-5/8" 1-15/32" 15-11/16"

40AF-P80CX1234512345 66ABCDEFGHABCDEFGHCONTROL BOX PARTS1-82-181-72-42-12-62-52-126-42-76-52-96-162-36-52-102-172-132-26-56-36-62-156-166-42-42-142-82

41AF-P80CX1234512345 66ABCDEFGHABCDEFGHCYCLE PARTS6- 13-63-123-113-53-23-132-162-116-76-103-83-43-73-96-173-106-173-31-186-103-11-192-101-391-32

42AF-P80CX

43AF-P80CX

44AF-P80CX’02 SHARP CORP. (3U0.85E) Printed in U.S.A.COPYRIGHT © 2002 BY SHARP CORPORATIONALL RIGHTS RESERVED.No part of this publication may be repro

5AF-P80CXHOW TO OPERATEPARTS NAMESUNITCONTROL PANEL1Front Cabinet2Air Inlet (Indoor Side)3Horizontal Louvers4Vertical Louvers5Air Outlet (Indoor Si

6AF-P80CX---Lower temp.---Raise temp.Touch POWER ON/OFF pad.• The unit is preset at 74°F and HIGHCOOL. This will show in the displaywhen the power i

7AF-P80CXTO CHANGE FAN SPEED AND OPERATION MODEDuring operationTouch SELECTOR pad and select theoperation mode and fan speed.• SELECTOR indicator and

8AF-P80CXENERGY SAVERTO CHANGE AIR FLOW DIRECTIONHorizontal louversAdjust UP/DOWN air flowThe horizontal louvers are used to adjust the UP / DOWN dire

9AF-P80CXON TIMER OPERATION(If you wish to start the operation6 hours and 30 minutes later, setthe delay time as shown above.)1Touch the TIMER ON/OFF